EquipmentRecall 06V-027 · 2004–2005 Girardin MB IV
GIRARDIN MINIBUS INC. recall 06V-027 covers 13 2004–2005 Girardin MB IV for a equipment problem, reported to NHTSA on February 2, 2006.
Source: NHTSA recall 06V027000 and manufacturer quarterly reports. Started by an NHTSA defect investigation.
The problem
CERTAIN GIRARDIN 2004 AND 2005 MB IV SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN JULY 6, 2004, AND FEBRUARY 10, 2005, EQUIPPED WITH CARRIER COMPRESSOR MOUNT BRACKETS, P/N 86-62400-00. THIS WELD IS USED TO MOUNT THE SECONDARY COMPRESSOR FOR THE SUPPLEMENTAL AIR CONDITIONING SYSTEM ON TO THE ENGINE. IF THE INSTALLER DOES NOT ADEQUATELY TORQUE THE MOUNTING HARDWARE OR THERE IS A POOR QUALITY WELD AT THE WELDMENT'S SUPPORT TAB, THE WELDMENT CAN BREAK OR FALL OFF.
The risk
IF THE WELDMENT BREAKS OR FALLS OFF, THE COMPRESSOR AND VACUUM PUMP COULD SHIFT CAUSING THE MISALIGNMENT AND EVENTUAL LOSS OF THE DRIVE BELT, POSSIBLY RESULTING IN THE LOSS OF OR IMPEDANCE TO THE VEHICLE'S PRIMARY BRAKING SYSTEM, AND COULD POTENTIALLY CAUSE A VEHICLE CRASH.
The fix
OWNERS ARE BEING INSTRUCTED TO CONTACT CARRIER AT 717-767-3359 OR VISIT THEIR WEBSITE AT WWW.TRANSICOLD.CARRIER.COM FOR FREE REMEDY. THE RECALL BEGAN ON FEBRUARY 15, 2006. OWNERS MAY ALSO CONTACT GIRARDIN MINIBUS SERVICE AND WARRANTY DEPARTMENT AT 819-477-8222.
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Recall repairs are free. Confirm whether this recall is open on your vehicle by entering its VIN at nhtsa.gov/recalls.
Vehicles in this recall
Built from July 6, 2004 to February 10, 2005. Not every vehicle in these model years is included; check by VIN.