12v/24v/48v battery: cablesRecall 99V-333 · Mitsubishi vehicles
MITSUBISHI AMERICA recall 99V-333 covers 19,179 Mitsubishi vehicles for a 12v/24v/48v battery: cables problem, reported to NHTSA on November 23, 1999.
Source: NHTSA recall 99V333001 and manufacturer quarterly reports. Started by the manufacturer.
The problem
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH V6 ENGINES AND FEDERAL EMISSION EQUIPMENT. THE BATTERY CABLE HARNESS CAN BECOME HEAT DAMAGED BY THE FRONT EXHAUST MANIFOLD WHICH COULD CAUSE GROUNDED CIRCUITS.
The risk
THIS CIRCUIT FAILURE COULD CAUSE ANY OF THE FOLLOWING TO OCCUR: (1) THE ENGINE WILL NOT START BECAUSE THE MAIN FUSE WILL BLOW IF THE POWER LEAD IS GROUNDED; (2) THE LOW OIL PRESSURE WARNING LAMP WILL ILLUMINATE IF THE SIGNAL WIRE IS GROUNDED; (3) THE AIRCONDITIONING SYSTEM WILL BECOME INOPERATIVE IF THE LEAD TO THE MAGNETIC CLUTCH IS GROUNDED; AND (4) THE TURN SIGNAL/HAZARD LAMPS WILL BECOME INOPERATIVE IF THE VOLTAGE MONITOR LEAD IS GROUNDED.
The fix
DEALERS WILL REMOVE AND DISCARD A METAL MANIFOLD BRACKET (FROM GALANT MODELS ONLY - ECLIPSE HAS NO SUCH BRACKET). DEALERS WILL ALSO INSPECT THE HARNESS. IF THE HARNESS WIRES SHOW NO DAMAGE, THE DEALER WILL INSTALL A HEAT INSULATOR ALONG WITH HEAT RESISTANT HARNESS CLIPS. IF THE HARNESS WIRES DO SHOW DAMAGE, THE DEALERS WILL INSTALL A NEW HARNESS WITH PREINSTALLED INTEGRAL HEAT PROTECTION.
OWNER NOTIFICATION BEGAN FEBRUARY 7, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Recall repairs are free. Confirm whether this recall is open on your vehicle by entering its VIN at nhtsa.gov/recalls.
Vehicles in this recall
Built from May 27, 1998 to November 30, 1999. Not every vehicle in these model years is included; check by VIN.